Your cart is empty.
Browse the store →
This test showed that the tendency to form lime deposits is reduced considerably by the “Vulcan 5000” water-treatment device. In addition, the effect continues for some days after “Vulcan 5000” has been switched off.
Under 1 year, with the Vulcan treatment it has already cost less than full chemical treatment
The system Vulcan 5000 is an economic alternative to expensive heat exchangers, i.e. closed circulations of coolant with treated water. These heat exchangers cost about 5,000€. The device Vulcan 5000 has been used on a trial basis since the end of March to treat the coolant of our gas laser. On the 12th of December the company coherent GMBH checked the laser tubes for lime deposits on the ceramic surface. No lime deposits were detected, therefore, it is in all a positive result.
We installed several Vulcan units just before the water meters, which were always filled with calcium and often become clogged. Because of these problems, we would have to change them frequently.
After multiple problems with scale build-up in our irons and laundry equipment we decided to try and solve this situation. After much research, we finally found the solution we were looking for. We chose the innovative line of water treatment, Vulcan. The Vulcan S25 unit was installed.
We have a total of 478 water outlets in the building (289 water taps, 97 toilets, 92 showers). We face an annual water consumption of approximately 75,478 US gallons where a chemical system would cause tremendous costs and maintenance work for us. When checking the water tap outlets and showers we no longer find the typical scale build up or blockages. We have an indoor swimming pool which we use for all medical therapies. In this area we are also fully content with the effect of the water treatment.
The entire piping system and equipment have a lot of scale. After Vulcan was installed for two months, by observing the faucet, we found the scale was reduced in the pipe and equipment and the water feels softer. The Hospital provides public health and basic medical services for more than 40,000 people. It is also responsible for emergency tasks of 200,000 people in eastern Jinzhou.
We have had the Vulcan S 250 installed inside the hospital now for a couple of months. We can identify a considerable benefit of the unit installed. We can barely see any scale deposits on the shower heads any more. This saves manpower and costs associated with exchanging sanitary equipment.
Installing the Vulcan S25 device, I found out that there are not any more white sedimentation on the leaves and soil. Most of all I realized that there is a big improvement in the growth of my plants. I also found out that there is a better and quicker foam creation whenever we want to wash our hands or clothing.
After the installation of your water treatment system in our bistros I noticed a clear improvement of the situation. The lime scale deposits are now much easier to remove thus easing the workload of the staff. Less detergent is needed and I am altogether extremely satisfied with your device.
We decided to replace the water softener with the Vulcan Descaler 3000 unit. The result now is amazing, the clogging of the shower nozzles is gone, and the kitchen faucet nozzles are spraying evenly and our commercial grade dishwasher is cleaner and works better. We use a lot less detergent when doing laundry as the Vulcan 3000 makes the detergent work so much better.
I believe we have quadrupled the life span of our evaporated air conditioner and we haven't had to replace our hot water system for more three years. Without the Vulcan Descaler Treatment System we would be replacing our hot water system every two years at a cost of more than $10,000.
The Vulcan S100 electronic Hard Water Descaler was installed to solve a serious mineral scaling problem in the cooling tower.
The world's leading producer of primary and fabricated aluminum, as well as the world's largest miner of bauxite and refiner of alumina. Their facilities in France produce technologically advanced products that include aluminum sheets and plates, aluminum architectural products and systems, fasteners and fastener installation systems, structural castings, turbine engine components and aircraft frame components.
The water treatment system Vulcan S25 protects the entire water supply network and all the heating devices of the pools of the Średzki Water Park. The costs of normal treatment products with such a water flow of 25 m3/h would mean operating costs at € 3,900 per month (assuming 24 working per hour)! The cost of running the Vulcan S25 device is approx. € 1.50 per month.
The visible scale deposits are less and the cleaning is much easier than without Vulcan – with less need of chemicals. Also the scale deposits of the cisterns and shower heads are much less, so we have less maintenance costs. We recommend your Vulcan system and we will install more Vulcan systems in further of our sanitary stations in Switzerland.
It has now been 4 months since installation of the Vulcan S100, and the scale problem have reduced significantly. Now the pipes and production equipment require much less cleaning. We are very satisfied with the performance of the Vulcan S100 Unit.
The Vulcan descaler device not only saved our company a lot of water treatment costs, but also significantly lowered our filter cloth costs and the labor workload requird to deal with our mineral scale problems.
The Vulcan S100 unit was installed on the water main for the Clubhouse, to protect the bathrooms and kitchen areas from limescale deposits
After the Vulcan installation, scale deposits were no longer found on the pumps, filters, nozzles and brushes. Detergent use was reduced dramatically, and now the recently washed automobiles show no signs of scale spotting.
The units, which allow scale particles to be washed away, are not only proving to be successful in commercial and industrial applications, but in private homes with scale and rust problems.
After confirming the effectiveness of the Vulcan, we have installed S100 units on all 5 washing stations within the Chicago IFCO plant.
Shop with an expert. We're here to help.
Call us: 412-848-5058
sales@vulcandescaler.com
VulcanDescaler.com is owned and managed by Waslix, LLC. Vulcan and its logos are registered trademarks of CWT (Germany).